Lopi Revere User Manual Page 1

R e v e r e Fireplace InsertOwner'sManual• Masonry FireplaceInsert• Zero-Clearance(Metal) FireplaceInsertSave these instructionsfor future ref

10 Stove Installation (for qualified installers only)© Travis Industries 100-01165 4040806Zero-Clearance (Metal) Fireplace Requirements• Must utilize

Stove Installation (for qualified installers only) 11© Travis Industries 100-01165 4040806Block-Off Plate InstallationWhenever this appliance is insta

12 Stove Installation (for qualified installers only)© Travis Industries 100-01165 4040806Insert withPositiveConnectionNOTE:Most factory-builtchimney

Stove Installation (for qualified installers only) 13© Travis Industries 100-01165 4040806Insert with DirectConnection (Z.C.Fireplace)NOTE:Direct conn

14 Operating Your Appliance© Travis Industries 100-01165 4040806Safety Notice:If this appliance is not properly installed, a house fire may result. Fo

Operating Your Appliance 15© Travis Industries 100-01165 4040806Bypass OperationThe bypass controls the flow of smoke inside the heater. When pulled

16 Operating Your Appliance© Travis Industries 100-01165 4040806Starting a FireSince the dawn of time man has debated the best way to start a fire. S

Operating Your Appliance 17© Travis Industries 100-01165 4040806Adjusting the Burn RateUse the air control slider to control the burn rate of the stov

18 Operating Your Appliance© Travis Industries 100-01165 4040806Optional Blower OperationThe blower will turn on once the stove is up to temperature.

Operating Your Appliance 19© Travis Industries 100-01165 4040806Hints for Burning• Get the appliance hot before adjusting to low burn• Use smaller p

2 Introduction© Travis Industries 100-01165 4040806IntroductionWe welcome you as a new owner of a Lopi Revere wood-burning fireplace insert. In purch

20 Operating Your Appliance© Travis Industries 100-01165 4040806TroubleshootingProblem Possible CauseSmoke Enters Room DuringStart-Up• Open the bypas

Maintaining Your Appliance 21© Travis Industries 100-01165 4040806Failure to properly maintain and inspect your appliance may reduce the performance a

22 Maintaining Your Appliance© Travis Industries 100-01165 4040806Monthly Maintenance (while appliance is in use)Make sure the appliance has fully coo

Maintaining Your Appliance 23© Travis Industries 100-01165 4040806Yearly MaintenanceMake sure the appliance has fully cooled prior to conducting servi

24 Maintaining Your Appliance© Travis Industries 100-01165 4040806Door Parts9/16" Wrench510891276341211NOTE: Place the glass gasket around the pe

Maintaining Your Appliance 25© Travis Industries 100-01165 4040806Firebox Parts134267598111111111013121111141111111111ID # Description Qty Part # ID #

26 Maintaining Your Appliance© Travis Industries 100-01165 4040806Baffle Removal & Replacement1 Push the front firebricks up and feed them forwar

Limited 7 Year Warranty27© Travis Industries 100-01165 4040806To register your TRAVIS INDUSTRIES, INC. 7 Year Warranty, complete the enclosed warranty

28 Listing Label© Travis Industries 100-01165 4040806Listing LabelCONTACT YOUR LOCAL BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS ANDINSTALLATION INS

Optional Equipment 29© Travis Industries 100-01165 4040806Door Shell InstallationPart Numbers: Black # 99300195, Brass # 9930096, Pewter # 993001971

Table of Contents 3© Travis Industries 100-01165 4040806General InformationIntroduction ...2Importa

30 Optional Equipment© Travis Industries 100-01165 40408063 Attach the retainer to the shell following the directions below.Make sure the door retain

Optional Equipment 31© Travis Industries 100-01165 4040806Surround PanelsRectangular Panels:SURROUND PANEL SIZE HEIGHT WIDTH8"27 5/8"40 3/8

32 Optional Equipment© Travis Industries 100-01165 40408062. Adjust the position of the side panels so they are: 1) flush with the bottom of the inser

Optional Equipment 33© Travis Industries 100-01165 4040806Front Blower (part # 99000133)To Switch The Power Cord To The Left Side:Use a pair of pliers

34 Index© Travis Industries 100-01165 4040806Air Control (Burn Rate) ...17Air Tube Part Number ...

4 Safety Precautions© Travis Industries 100-01165 4040806The viewing door must beclosed and latched duringoperation.Never block free airflow throughth

Safety Precautions 5© Travis Industries 100-01165 4040806MobileHomeWhen installed in a mobilehome, this appliance must bebolted to the floor, have out

6 Features & Specifications© Travis Industries 100-01165 4040806Installation Options:• Masonry Fireplace Insert• Zero-Clearance (Metal) Fireplac

Stove Installation (for qualified installers only) 7© Travis Industries 100-01165 4040806SAFETY NOTICE:Please read this entire manual before you insta

8 Stove Installation (for qualified installers only)© Travis Industries 100-01165 4040806Fireplace RequirementsFigure 2 shows the minimum size require

Stove Installation (for qualified installers only) 9© Travis Industries 100-01165 4040806Insert Placement Requirements• The insert must be placed so